The effect of bagasse pith xylose on yeast growth kinetic in bio-products manufacture

Document Type : Research Paper

Authors

1 M. Sc. Student, Department of bio-refinery engineering, Faculty of new technologies, Zirab campus, Shahid Beheshti university, Savadkooh, Iran

2 Assistant Prof., Department of bio-refinery engineering, Faculty of new technologies, Zirab campus, Shahid Beheshti university, Savadkooh, Iran

3 Assistant Prof., Department of bio-refinery engineering, Faculty of new technologies, Zirab campus, Shahid Beheshti University, Savadkooh, Iran

Abstract

In order to Xylan extraction, bagasse pith, after alkaline pre-treatment and sodium chlorite bleaching, treated with different dosage of soda and then calculated extraction percentage and characterized with FT-IR. Produced xylan changed to xylose with diluted acid hydrolysis and after treatment with active carbon and ultrasonic, reduced sugar measured by HPLC. Then, obtained xylose was added to yeasts media of kluyveromyces marxianus and pichia stipites to evaluate its effects on their growth kinetic. Results showed that by increasing in soda dosage, xylan extraction percentage increased. Also, hydrolysis process alone can produced much sugar without active carbon and ultrasonic. Evaluation of yeasts growth kinetic showed that the speed of yeast growth in media including xylose was more than glucose one and so efficiency of these yeasts is much for C5 sugar as it can be used them for bio-products manufacture.

Keywords


 
[1] Chandel, A. K., da Silva, S. S., Carvalhoa, W. and Singh, O. V., 2012. Sugarcane bagasse and leaves: foreseeable biomass of biofuel and bio-products.Journal of Chemical Technology and Biotechnology, 87: 11–20.
[2] Rafiei, A. and Jonoobi, M., 2006. Sugar cane; industrial plant. Monthly Journal of Wood and Paper, 21: 24-27. (In Persian).
[3]Lois-Correa, J. A., 2012. Depithers for efficient preparation of sugar cane bagasse fibers in pulp and paper industry. Ingeniería Investigación y Tecnología, 13(4): 417-424.
[4] Jain, R. K., 2011. Bioethanol from bagasse pith a lignocellulosic waste biomass from paper/suger industry. Indian Pulp & Paper Technical Association journal, 23(1): 169-173.
[5] Sanjuan, R., Anzaldo, J., Vargas, J., Turrado, J. and Patt, R., 2001. Morphological and chemical composition of pith and fibres from mexican sugarcane bagasse. Holzals Roh-und Werkstoff, 59: 447–450.
[6] Djafari Petroudy, S. R., Ghasemian, A., Resalati, H., Syverud, K. and Chinga-Carrasco, G., 2015. The effect of xylan on the fibrillation efficiency of DED bleached soda bagasse pulp and on nanopaper characteristics. Cellulose, 22: 385-395.
[7] Dadi, A., Varanasi, S. and Schall, C., 2006. Enhancement of Cellulose Saccharification Kinetics Using an Ionic Liquid Pretreatment Step. Biotechnology andBioengineering, 95: 904-910.
[8] Fakour Jannati, S., Fanaee shekholeslami, M. and Maskooki A., 2010. Production of bio-ethanol from lignicellulosic waste: optimization of pre-treatment stage by concentrated acid, 1st conference of separation science and engineering, Shahid Bahonar University,May 19-21, Kerman, Iran, p. 1-8. (In Persian).
[9]Nikolic, S., Mojovic, L., Rakin, M., Pejin, D. and Pejin, J., 2011. Utilization of microwave and ultrasound pretreatments in the production of bioethanol from corn, Clean Technologies and Environmental Policy, 13: 587–594 .
[10]Toma, M., Bandow, H., Vinatoru, M. and Maeda, Y., 2006. Ultrasonically Assisted Conversion of Lignocellulosic Biomass to Ethanol, In: Proceedings of AIChE Annual Meeting Conference, Nov. 12-17, San Francisco, United States, 701a: l-7.
[11] Stabnikova, O., Wang, J-Y. and Ivanov, V., 2010. Value-Added Biotechnological Products from Organic Wastes. Handbook of Environmental Engineering, Volume 10: Environmental Biotechnology, Springer Science + Business Media, p. 343-394.
[12] Harner, N. K., Bajwa, P. K., Habash, M. B., Trevors, J. T., Austin, G. D. and Lee, H., 2014. Mutants of the pentose-fermenting yeast Pachysolen tannophilus tolerant to hardwood spent sulfite liquor and acetic acid. Antonie van Leeuwenhoek, 105(1): 29–43
[13] Bajwa, P. K., Shireen, T., D'Aoust, F., Pinel, D., Martin, V. J. J., Trevors, J. T. and Lee, H., 2009. Mutants of the pentose-fermenting yeast Pichia stipitis with improved tolerance to inhibitors in hardwood spent sulfite liquor. Biotechnology and Bioengineering, 104(5): 892–900
[14] Sixta, H., 2006. Handbook of Pulp. WILEY-VCH Verlag GmbH & Co. KGaA, Weinheim, Germany, 1101p.
[15] McMillan, J. D., 1993.Xylose Fermentation to Ethanol: A Reveiw, National Renewable Energy Laboratory, USA, 45 p.
[16] Hamidimotlagh R., Nahvi I., Emtiazi G. and Ghezelbash, Gh., 2009. Isolation and Identification of Ethanol Producer Yeasts from D-Xylose. Iranian Journal of Biology, 22(1): 46-52. (In Persian).
[17] Bianfang, L., Zh. S., Wang, G., Chen, Y., Ren, Zh., Xu, Q. and Yan, Y., 2013. Acid pretreatment of bagasse pith at low temperature with steam-assisted heating. Journal of Renewable and Sustainable Energy, 5(4): 1-9
[18] Dasgupta, D., Suman, S. K., Pandey, D., Ghosh, D., Khan, R., Agrawal, D., Jain R. K., Vadde, V. T. and Adhikari D. K., 2013. Design and optimization of ethanol production from bagasse pith hydrolyzate by a thermotolerant yeast Kluyveromyces sp. IIPE453 using response surface methodology, Springer Plus, 2:159
[19]Najafi, G., Ghobadian, B., Tavakoli, T. and Yusaf, T., 2009. Potential of bioethanol production from agricultural wastes in Iran. Renewable and Sustainable Energy, 13(6/7): 1418-1427.
[20] Wise, L. E., Murphy, M., D’Addieco, A. A., Pap. and Trade J., 1946. Chlorite holocellulose, its fractionation and bearing on summative wood analysis and studies on the hemicelluloses. Paper Trade Journal, 122(2): 35-43.
[21] Converti, A., Dominguez, J. M., Perego, P., Da Silva, S. S. and Zilli, M., 2000. Wood hydrolysis and hydrolyzate detoxification for subsequent xylitol production. Chemical Engineering and Technology, 23(11): 1013-1020.
[22] Sene, L., Vitolo, M., Felipe, M. G. A. and Silva, S. S., 2000. Effects of Environmental Conditions On xylose Reductase and Xylitol Dehydrogenase Production by Candida guilermondii, Application of Biochemical Bioengineering, 84-86: 371-380.
[23] Caputir A. and Ueda M., 1968 Spectrophotometric determination of ethanol in wine. American Journal of Enology and Viticulture, 19 (3): 160-165.
[24] Sun, R. C.and Tomkinson, J., 2002. Characterization of hemicelluloses obtained by classical and ultrasonically assisted extractions from wheat straw. Carbohydrate Polymers, 50: 263–271.
[25] Wang, B., Wang, X. and Feng, H., 2010. Deconstructing recalcitrant miscanthus with alkaline peroxide and electrolyzed water. Bioresource Technology, 101: 752–760.
[26] Egues, I., Sanchez, C., Mondragon, I. and Labidi, J., 2012. Effect of alkaline and autohydrolysis processes on the purity of obtained hemicelluloses from corn stalks. Bioresource Technology, 103: 239-248.
[27] Sun, R. C. and Tomkinson, J., 2002. Characterization of hemicelluloses obtained by classical and ultrasonically assisted extractions from wheat straw. Carbohydrate Polymers, 50: 263–271.
[28] Oh, S. Y., Yoo, D. I., Shin, Y., Kim, H. C., Kim, H. C., Chung, Y. S., Park, W. H. and Youk, J. H., 2005. Crystalline structure analysis of cellulose treated sodium hydroxide and carbon dioxide by mean of X-ray diffraction and FTIR spectroscopy. Carbohydrate Research, 340: 2376–2391.